CHAPTER IX.

LAKES.

Organic colouring matters for use as pigments are mostly made in the form of “lakes,” by one of the three following methods:--

(_a_) To a filtered solution of the colouring matter is added a solution of alum; the whole is agitated, and the colour is precipitated by a solution of carbonate of potash.

(_b_) A solution of the colouring matter is made in a weak alkaline lye, and precipitated by adding a solution of alum.

(_c_) Recently-precipitated alumina is agitated with a solution of the colouring matter as before, until the liquid is nearly decolorised, or the alumina assumes a sufficiently deep tint. The first method is generally adopted for acidulous solutions of colouring matter, or those injured by alkalies; the second for those not injured by alkalies; the third, for those whose affinity for gelatinous alumina enables them to combine with it by mere agitation.

Alumina in a state suitable for the preparation of the pigments known as “lakes” may be produced in the following manner:--Dissolve 1 lb. of alum in ½ gallon of water, and add 75 grains of sulphate of copper, and about ¼ lb. of zinc turnings; leave the mixture for three days in a warm place, renewing the water lost by evaporation. The copper is first deposited upon the zinc, the two metals thus forming a voltaic couple sufficiently strong. Hydrogen is disengaged, sulphate of zinc is formed, and the alumina gradually separates in the state of a very fine powder; the action is allowed to continue until there is no more alumina left in solution, or until ammonia ceases to give a precipitate. If the reaction is prolonged beyond this point, oxide of iron will precipitate if present. The alumina washes easily, and does not contract upon drying.

BRAZIL-WOOD LAKE.--(_a_) Digest 1 lb. ground Brazil-wood in 4 gal. water for 24 hours, boil ½ hour, and add 1½ lb. alum dissolved in a little water; mix, decant, strain, add ½ lb. tin solution, again mix well, and filter; to the clear liquid cautiously add a solution of carbonate of soda while a precipitate forms, avoiding excess; collect, wash, and dry. The shade will vary according as the precipitate is collected.

(_b_) Add washed and recently-precipitated alumina to a strong filtered decoction of Brazil-wood.

CARMINATED LAKE.--(_a_) The cochineal residue left in making carmine is boiled with repeated portions of water till exhausted; the liquor is mixed with that decanted off the carmine, and at once filtered; some recently-precipitated alumina is added, and the whole is gently heated, and well agitated for a short time. As soon as the alumina has absorbed enough colour, the mixture is allowed to settle, the clear portion is decanted, and the lake is collected on a filter, washed, and dried. The decanted liquor, if still coloured, is treated with fresh alumina till exhausted, and thus a lake of second quality is obtained.

(_b_) To the coloured liquor obtained from the carmine and cochineal as just stated, a solution of alum is added, the filtered liquor is precipitated with a solution of carbonate of potash, and the lake is collected and treated as before. The colour is brightened by addition of tin solution.

CARMINE.--Boil 1 lb. cochineal and 4 dr. carbonate of potash in 7½ gal. water for ¼ hour. Remove from the fire, and stir in 8 dr. powdered alum, and allow to settle for 20 to 30 minutes. Pour the liquid into another vessel, and mix in a strained solution of 4 dr. isinglass in 1 pint water; when a skin has formed upon the surface, remove from the fire, stir rapidly, and allow to settle for ½ hour, when the deposited carmine is carefully collected, drained, and dried.

COCHINEAL LAKE.--(_a_) Digest 1 oz. coarsely powdered cochineal in 2½ oz. each water and rectified alcohol for a week; filter, and precipitate by adding a few drops of tin solution every 2 hours, till the whole of the colouring matter is thrown down; wash the precipitate in distilled water, and dry.

(_b_) Digest powdered cochineal in ammonia water for a week; dilute with a little water, and add the liquid to a solution of alum as long as any precipitate (lake) falls.

(_c_) Boil 1 lb. coarsely powdered cochineal in 2 gal. water for 1 hour; decant, strain, add solution of 1 lb. cream of tartar, and precipitate with solution of alum. By adding the alum first and precipitating the lake with the tartar, the colour is slightly changed.

MADDER LAKE.--(_a_) Tie 2 oz. madder in a cloth, beat it well in a pint of water in a stone mortar, and repeat the process with about 5 pints of fresh water till it ceases to yield colour; boil the mixed liquor in an earthern vessel, pour into a large basin, and add 1 oz. alum dissolved in 1 pint boiling water; stir well, and gradually pour in 1½ oz. of strong solution of carbonate of potash; let stand until cold, pour off the yellow liquor from the top, drain, agitate the residue repeatedly in 1 qt. boiling water, decant, drain, and dry.

(_b_) Add a little solution of acetate of lead to a decoction of madder, to throw down the brown colouring matter; filter, add solution of tin or alum, precipitate with solution of carbonate of soda or potash, and proceed as before.

(_c_) Macerate 2 lb. ground madder in 1 gal. water for 10 minutes; strain and press quite dry; repeat a second and third time, and add to the mixed liquors ½ lb. alum dissolved in 3 qt. water; heat in water-bath for 3-4 hours, adding water as it evaporates; filter first through flannel, and when cold enough through paper; add solution of carbonate of soda as long as precipitate falls; wash the latter till the water comes off colourless, and dry.

YELLOW LAKES.--(_a_) Boil 1 lb. Persian berries, quercitron-bark, or turmeric, and 1 oz. cream of tartar, in 1 gal. water till reduced to half; strain the decoction, and precipitate by solution of alum.

(_b_) Boil 1 lb. of the dyestuff with ½ lb. alum in 1 gal. water, and precipitate by solution of carbonate of potash.

(_c_) Boil 4 oz. annatto and 12 oz. pearlash in 1 gal. water for ½ hour; strain, precipitate by adding 1 lb. alum dissolved in 1 gal. water till it ceases to produce effervescence or a precipitate; strain and dry.

For information concerning the numerous coal-tar colours now largely manufactured into lakes, the reader is referred to “Spon’s Encyclopædia of Industrial Arts.”